An Alternative to Waste Incinerators

  • A new process called alkaline hydrolysis is forecasted to be a cheaper, safer way to dispose of animal carcasses. (Photo by Dr. Beth Williams, University of Wyoming, courtesy of CWD Alliance)

Animal research labs usually get rid of carcasses by burning them in incinerators. Now, a new more environmentally friendly technology is being used to dispose of the diseased dead animals and the lab supplies they contaminate. The new method has worked well enough that hospitals are considering it as a way to dispose of medical waste. The Great Lakes Radio Consortium’s Julie Halpert reports:

Transcript

Animal research labs usually get rid of carcasses by burning them in incinerators. Now, a new more environmentally friendly technology is being used to dispose of the diseased dead animals and the lab supplies they contaminate. The new method has worked well enough that hospitals are considering it as a way to dispose of medical waste. The Great Lakes Radio Consortium’s Julie Halpert reports:


Until recently, the only safe way to destroy diseased tissue and other infectious waste was to burn it in an incinerator. But dangerous chemicals such as dioxins spew from the incinerator smokestacks, and burning leaves behind a toxic ash.


(sound of machine whirring)


Now, there’s an alternative to burning. Dr. Gordon Kaye stands in a spotless room beside one of the units manufactured at a company he helped found, WR Squared, in Indianapolis, Indiana. The unit will eventually be used to dispose of 5,000 pounds of dead animals – about the equivalent of five large cows – that were used for veterinary research.


But there will be no smoke. There’ll be no fire.


Kaye’s idea for a new type of disposal technology began 12 years ago when he was a pathology professor at Albany Medical College. He was frustrated with how much it cost to dispose of dead research animals. So, he started experimenting with a new technology. And alkaline hydrolysis was born.


“Well, there are no air emissions from it. It’s a sealed system. It takes place in a hermetically sealed pressure vessel. No dangerous products are produced in it because of the temperature which it takes place.”


Alkaline hydrolysis works like this: infectious waste goes into a tightly sealed vessel, along with strong alkalis which are very caustic. The waste is then cooked at temperatures well above boiling. A chemical reaction causes the waste to break down. The infectious components are neutralized. When it’s over, you end up with two products: a sterile, water-like solution, that can head to a sanitary sewer system, and sterile crushed bones, the consistency of powder, that can be used as fertilizer. Because the end products are clean, they don’t require complicated disposal, so the process is cheaper than incineration.


WR squared now has 60 units in 15 states, primarily at research facilities. The U.S. Department of Agriculture has purchased several of them. New York was the first state to allow use of the technology. Ira Salkin directed that state’s medical waste program when it approved WR squared’s process.


“It has less potential problems than is being found with incineration and the use of incineration in the U.S. is decreasing and therefore their system holds great promise. As the numbers of incinerators decrease, one finds they have this alternative to be used to treat pathologic material.”


Environmentalists agree with Salkin that the technology is sound. Horhay Emmanuel is with Health Care Without Harm. He notes that it’s especially effective for one troublesome type of waste, cattle dead from Mad Cow disease.


“Not only does it destroy infectious agents, but it also destroys prion-contaminated waste. And prions are what are believed to cause things like Mad Cow disease, which are difficult to destroy, even by incineration, so WR squared has been shown to destroy these prions in the contaminated waste.”


Last April, The Environmental Protection Agency approved alkaline hydrolysis, along with incineration, as a way to treat Mad Cow diseased waste. And WR Squared’s Gordon Kaye sees that as a big future market.


Horhay Emmanuel, with Health Care Without Harm, says while alkaline hydrolysis is generally good for the environment, there is one concern. The fluid that’s produced could overwhelm some small town’s sewer systems. The company says in communities with small sewer systems, the solution can be released more slowly or during off-peak hours.


So, alkaline hydrolysis process is cheaper, it pollutes less, government agencies like it, and environmentalists find little to criticize.
Now, the company is broadening its reach to treat hospital waste. Many hospitals are using smaller, not very efficient incinerators that pollute more.


WR Squared’s Gordon Kaye says he expects big growth with this new method to dispose of medical and infectious waste as labs and hospitals look for ways to replace their incinerators over the next several years.


For the GLRC, I’m Julie Halpert.

Related Links